Page 1 ORDER NO.DSD0304007C1 DVD Video Recorder DMR-E60PP Colour (S).......Silver Type SPECIFICATIONS Specifications Power supply: AC120 V, 60 Hz Power consumption: 28 W Recording system: DVD video recording standards (DVD-RAM), DVD video standards (DVD- Optical pick-up: System with 1 lens, 2 integration units (662 nm...
Page 2 Discs played: 12 cm 4.7 GB DVD-RAM discs 12 cm 9.4 GB DVD-RAM discs 8 cm 2.8 GB DVD-RAM discs 12 cm 4.7 GB DVD-R discs 8 cm 1.4 GB DVD-R discs (for General Ver. 2.0) DVD-VIDEO discs CD-Audiodiscs (CD-DA) Video CD discs DVD Audio CD-R/ CD-RW discs (CD-DA, Video CD, MP3...
Page 3 Antenna reception input: TV Channel: 2ch-69ch, 75 CATV Channel: 1ch-125ch, RF converter output: Not provided Audio system Recording system: Dolby Digital (XP/SP/LP/EP) LINEAR PCM (XP mode only) Input: LINE (pin jack) ×3 Reference input: 309 mVrms FS: 2 Vrms (1 kHz, 0 dB) Input impedance: 47 k Output: LINE (pin jack) ×2...
Page 4: Safety Precautions
2003 Matsushita Electric Industrial CO., Ltd. All rights reserved. Unauthorized copying and distribution is a violation of law. 1. SAFETY PRECAUTIONS 1.1. GENERAL GUIDELINES 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit.
Page 5: Leakage Current Hot Check
1.1.2. LEAKAGE CURRENT HOT CHECK (See Figure 1 1. Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check. 2. Connect a 1.5k , 10 watts resistor, in parallel with a 0.15 capacitors, between each exposed metallic part on the set and a good earth ground such as a water pipe, as shown in Figure 1...
Page 6: Precaution Of Laser Diode
place the assembly on a conductive surface such as alminum foil, to prevent electrostatic charge buildup or exposure of the assembly. 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as "anti-static (ESD protected)"...
Page 7: How To Replace The Lithium Battery
( As shown in 15.2.1. The Main P.C.B. ) NOTE: The lithium battery is a critical component. ( Type No.: CR2032-1GUF Manufactured by Panasonic. ) It must never be subjected to excessive heat or discharge. It must therefore only be fitted in equipment designed specifically for its use.
Page 8: Handling The Lead-Free Solder
5. Handling the Lead-free Solder 5.1. About lead free solder (PbF) Caution: - Pb free solder has a higher melting point than standard solder; Typically the melting point is 50 - 70°F (30 - 40°C) higher. Please use a high temperature soldering iron. In case of the soldering iron with temperature control,please set it to 700 ±...
Page 9 SKIP(R), TIME SLIP, and OPEN / CLOSE simultaneously for five seconds. 2. For disassembly and replacement procedures, refer to the “Assembling and Disassemling”. 6.1. Service Explorer Express The following steps allow you to check each block separately (Digital P.C.B., RAM drive, Main / Power Supply / Front P.C.B.).
Page 10 6.2. Service Explorer in Detail 6.2.1. Does not operate items needed: RAM drive, digital P.C.B., remote control. Conditions: Nothing special.
Page 11 6.2.2. Poor Pictures Items needed: RAM drive, Digital P.C.B., RF cable, AV cable. Conditions: Check with TU IN-AV OUT(EE). When recording or playback is partially needed, follow the instructions.
Page 12 6.2.3. Some defective functions Items needed: PC card adaptor (media), Digital P.C.B. conditions: Nothing special...
Page 13 6.2.4. Other Items needed: Digital P.C.B., HDD. Conditions: Nothing special.
Page 14: Standard Inspection Specifications After Making Repairs
Procedure Item to Check Turn on the power. The Panasonic RAM disc should be recognized. Enter the EE (TU IN / AV IN - AV OUT) mode. No abnormality should be seen in the picture, sound or operation. Perform auto recording and playback for one No abnormality should be seen in the picture, minute using the RAM disc.
Page 15: Assembling And Disassembling
8. Assembling and Disassembling 8.1. Disassembly flow chart The following chart is the procedure for disassembling the casing and inside parts for internal inspection when carrying out the servicing. To assemble the unit, reverse the steps shown in the chart below. 8.2.
Page 16 8.4. The Front panel 1. Remove the 2 tab (A) and 3 tab (B) in this order. (The tab (A) and the tab (B) should be removed at the same time, respectively.) 2. Move the front panel to your side slowly and remove it. 8.5.
Page 17 1. Remove the 2 screws and remove the Front Angle with Earth Plate. 2. Remove the 4 screws and remove the Front (R) P.C.B. 8.6. The Front (L) and DV Jack P.C.B. 1. Remove 1screw inside of the Front panel door with a precision screw driver.
Page 18 8.7. The SD & PC card P.C.B. 1. Remove the 4 screws. 2. Pull out the SD & PC card P.C.B. vertically. 8.8. The Digital P.C.B. 1. Remove the 4 screws and 3 tabs and remove the angle. 2. Remove the FFC. CAUTION: When replacing Digital P.C.B., pay attention as below.
Page 19 3. Pull out the Digital P.C.B. vertically with paying attention to 3 Connectors. 8.9. The DVD-RAM Drive 1. Remove the 4 screws. 2. Pull out the DVD-RAM Drive vertically and remove the connector.
Page 20 8.10. The Rear panel 1. Remove the Fan Motor connector. 2. Remove the 5 screws (A) and 1screw (B). 3. Remove the 2 tabs and remove the Rear panel. 8.10.1. In case of removing Fan motor from Rear panel 1. Remove a screw. 2.
Page 21: Service Positions
8.11. The Main Power Supply P.C.B. and Main P.C.B. 1. Remove the 2 connectors. 2. Remove the 3 screws (A) and 2 tab (A). 3. Remove the Main Power Supply P.C.B and tab (B) , pull out it in the direction of the arrow. 4.
Page 22 Note: For the disassembling procedure, see the section 8. 9.2. Checking the Digital P.C.B. and SD & PC Card P.C.B. 1. Remove the Top Cover. 2. Remove the SD & PC Card P.C.B. and angle. 3. Remove the FFC (RAM Drive - Digital P.C.B.). 4.
Page 23 9.3. Checking the Main P.C.B. 1. Remove the Top Cover. 2. Remove the Front Panel. 3. Remove the Rear Panel. 4. Remove the Power Supply P.C.B., Main P.C.B. and RAM Drive. 5. Use the extension cable (RFKZ0168) to connect the Main P.C.B. and Fan Motor.
Page 24 Service tools Extension Cable RFKZ0165 (20Pin) (Main P.C.B. - Front (L) P.C.B.) Extension Cable RFKZ0166 (10Pin) (Power supply P.C.B. - Front (R) P.C.B.) Extension Cable RFKZ0168 (3Pin) (Fan motor) 9.4. Checking the Power Supply P.C.B. 1. Remove the Top Cover. 2.
Page 25 7. Use the extension cable (RFKZ0166) to connect the Power Supply P.C.B. and Front (R) P.C.B. Service tools Extension Cable (Main P.C.B. - RFKZ0165 (20-pin) Front (L) P.C.B.) Extension Cable (Power RFKZ0166 (10-pin) supply P.C.B. - Front (R) P.C.B.) Extension Cable (Main P.C.B. - RFKZ0170 (19-pin) Power supply P.C.B.) Extension Cable (Main P.C.B.
Page 26: Volume Up/Down
Each buttons Functions name To turn power on or off on the DVD. VIDEO Plus+ To set timer program using G (Show View/G code/Show view/VIDEO Plus+ code) To set AV input on the TV. Numeric To put each number for buttons(10key) selecting each functions.
Page 27: Rec Mode
Each buttons Functions name SLOW/SEARCH <SLOW> To set the slow mode during still. <SEARCH> To set the cue or review during playback. PLAY/X1.3 <PLAY> To set playing back. <X1.3> To set the times 1.3 speed for playback by keep pressing playback button for more than 1 second.
Page 28 Each buttons Functions name POSITION To memorize STOP position for MEMORY playing back again. * STOP position is erased by turning power off and openning tray. MARKER (DVD-RAM/-R)To put marker for making chapter. AV LINK To playback on the DVD and select AV1 mode on the TV automatically.
Page 29 Item FL display Key operation Mode name Description Remote controller key Clear item Items 1-20 are cleared. [0] [0] while in service mode Error code display FL display of the last [0] [1] while in service mode error code held by timer ROM version Region code, main,...
Page 30 Item FL display Key operation Mode name Description Remote controller key Magenta picture Magenta picture Initialization mode [1] [2] while in service mode output output from AV (Interlace) decoder Magenta picture (Chroma: 100%) Switching enabled by Progressive/ Interlace [1] [4] while in Magenta picture subcommand “I/P switched mode...
Page 31 Item FL display Key operation Mode name Description Remote controller key Audio Mute Check whether is [2] [2] while in service mode (XDMUTE) mute applied normally by the Digital P.C.B. (GLUE IC). Audio pattern The audio pattern Initialization mode [2] [3] while in service mode output stored in the internal (Interlace)
Page 32 Item FL display Key operation Mode name Description Remote controller key Factors which The disc condition is [4] [4] while in service mode cause drive error displayed when an error occures. Disc manufacture ID Display the [4] [5] while in service mode manufacture’s ID for a disc on which a drive error has occured.
Page 33 Item FL display Key operation Mode name Description Remote controller key Error code Initialization of the last [9] [8] while in service mode initialization error code held by timer (Write in F00) Main unit All parameters [9] [9] while in service mode initialization (including timer) are initiaized to the...
Page 34 Item FL display Key operation Mode name Description Remote controller key Model Since a drive region is When the power is off, press not specified [0] on SKIP(R), TIME SLIP and OPEN replacement drives, it CLOSE simultaneously for is specified when the seconds.
Page 35 Diagnosis Description FL display Display Remote control Display appears when main unit and remote mode error controller modes are not matched. Abnormal inner Display appears when the drive temperature temperature exceeds 71Åé. Main unit is detected powered off forcibly. For 30 minutes after this, all key entries are disabled.
Page 36 Diagnosis Description FL display Display Initialization Display appears when initialization error is error when main detected after starting up main microprocessor microprocessor for program recording. The is started up for event is saved in memory. program recording Remains displayed. Unsupported *A disc an unsupported format was played, UNSUPPORT disc error...
Page 37 10.3.3. Disk production maker ID * Since a display is arbitrarily set up by the disk producer side, the above-mentioned display may be changed. Please make it reference as an example of a display. 11. Abbreviations...
Page 38 INITIAL/LOGO ABBREVIATIONS A0~UP ADDRESS ACLK AUDIO CLOCK AD0~UP ADDRESS BUS ADATA AUDIO PES PACKET DATA ADDRESS LATCH ENABLE AMUTE AUDIO MUTE AREQ AUDIO PES PACKET REQUEST AUDIO RF SERVO AMP INVERTED INPUT SERVO AMPOUTPUT ASYNC AUDIO WORD DISTINCTION SYNC BIT CLOCK (PCM) BCKIN BIT CLOCK INPUT BLACK DROP OUT...
Page 39 INITIAL/LOGO ABBREVIATIONS DACCK D/A CONVERTER CLOCK DEEMP DEEMPHASIS BIT ON/OFF DEMPH DEEMPHASIS SWITCHING DIG0~UP FL DIGIT OUTPUT DATA INPUT DMSRCK DM SERIAL DATA READ CLOCK DMUTE DIGITAL MUTE CONTROL DROP OUT DOUT0~UP DATAOUTPUT DATA SLICE RF (BIAS) DROP OUT SIGNAL DRPOUT DATA REQUEST DREQ...
Page 40 INITIAL/LOGO ABBREVIATIONS IECOUT IEC958 FORMAT DATA OUTPUT IPFRAG INTERPOLATION FLAG IREF I (CURRENT) REFERENCE ISEL INTERFACE MODE SELECT LDON LASER DIODE CONTROL LASER POWER CONTROL LRCK L CH/R CH DISTINCTION CLOCK MA0~UP MEMORY ADDRESS MEMORY CLOCK MCKI MEMORY CLOCK INPUT MCLK MEMORY SERIAL COMMAND CLOCK...
Page 41 INITIAL/LOGO ABBREVIATIONS READ ENABLE RFENV RF ENVELOPE RF PHASE DIFFERENCE OUTPUT (CD-ROM) REGISTER SELECT RSEL RF POLARITY SELECT RESET RESERVE SBI0, 1 SERIAL DATA INPUT SBO0 SERIAL DATA OUTPUT SBT0, 1 SERIAL CLOCK SERIAL DATA CLOCK SCKR AUDIO SERIAL CLOCK RECEIVER SERIAL CLOCK SCLK...
Page 42 SUB CODE Q DATA SYSCLK SYSTEM CLOCK INITIAL/LOGO ABBREVIATIONS TRACKING ERROR TIBAL BALANCE CONTROL BALANCE OUTPUT 1 BALANCE INPUT BALANCE INPUT BALANCE OUTPUT 2 TPSN OP AMP INPUT TPSO OP AMP OUTPUT TPSP OP AMP INVERTED INPUT TRCRS TRACK CROSSSIGNAL TRON TRACKING ON TRSON...
Page 43: Voltage And Waveform Chart
INITIAL/LOGO ABBREVIATIONS X' TAL XALE X ADDRESS LATCH ENABLE XAREQ X AUDIO DATA REQUEST XCDROM X CD ROM CHIP SELECT X CHIP SELECT XCSYNC X COMPOSITE SYNC X DATA STROBE XHSYNCO X HORIZONTAL SYNC OUTPUT XHINT XH INTERRUPTREQUEST X' TAL OSCILLATOR INPUT XINT X INTERRUPT X MEMORY WRITE ENABLE...
Page 44: Block Diagram
13. Block Diagram 13.1. Power Supply Block Diagram 13.1.1. Integrated Circuit Power Supply Chart ( PSC 1 - PSC 17 ) 13.2. Analog Video Block Diagram 13.3. Analog Audio Block Diagram 13.4. Timer Block Diagram 13.5. Digital Section Block Diagram 13.5.1.
Page 45: Print Circuit Board
14.13. Glue Schematic Diagram (G) ( Digital P.C.B. 6/8 ) 14.14. 1394 DV Schematic Diagram (DV) (Digital P.C.B. 7/8) & DV JACK Schematic Diagram 14.15. Real Time Stream Control (RTSC) Schematic Diagram (DS) (Digital P.C.B. 8/8) 14.16. SD & PC Card Schematic Diagram 14.17.
Page 46 16.2. Casing Parts & Mechanism Section 2...
Page 47 16.3. Packing & Accessories Section...
Page 48: Replacement Parts List
17. Replacement Parts List Notes: *Important safety notice: Components identified by mark have special characteristics important for safety. Furthermore, special parts which have purposes of fire-retardant (resistors), high-quality sound (capacitors), low-noise (resistors), etc. are used. When replacing any of components, be sure to use only manufactures specified parts shown in the parts list.
Page 49 FRONT ORNAMENT(R) 20-11 RGK1674-K FRONT ORNAMENT(L) 20-12 RKF0668-S TRAY DOOR 20-13 VMB3410 BLINDER SPRING 20-14 XTN2+6G SCREW 20-15 VGB0560 PANASONIC BADGE 20-16 RMC0539 EARTH PLATE 20-17 RGL0620-Q LIGHTING PIECE 20-18 RKF0666E-S PANEL DOOR 20-19 XTBS26+8J SCREW 20-20 RMA1639 FRONT ANGLE...
Page 50 Ref. No. Part No. Part Name & Description Remarks 20-21 RMX0252 DAMPER SHEET 20-22 RMZ0693 SHEET VGQ5954 TAPE1 RGQ0324-K TAPE2 XTBS26+10J SCREW REP3528AB FRONT(L)P.C.B. (RTL) REP3528BA FRONT(R)P.C.B. (RTL) RMC0549 EARTH PLATE REP3540BA D & PC CARD P.C.B. (RTL) 36-1 VXA7527 PC CARD SLOT 36-2 XYN2+F6...
Page 51 Ref. No. Part No. Part Name & Description Remarks C1200 ECQV1H104JL3 50V 0.1U C1201 F1H1H473A783 50V 0.047U C1202 F1H1H104A783 50V 0.1U C1260,61 F2A1C6810023 16V 680U C1262 F2A1A1020054 10V 1000U C1271,72 F2A1C6810023 16V 680U C1302 ECA1AHG221 10V 220U C1304 ECA1AHG221 10V 220U C1401 F1H1H104A783 50V 0.1U...
Page 52 Ref. No. Part No. Part Name & Description Remarks P1103 K1KB15A00028 CONNECTOR(15P) P1104 K1KB10B00053 CONNECTOR(10P) Q1200,01 PC123ZY2 TRANSISTOR B3PBA0000078 Q1270 B1DHED000008 TRANSISTOR QR1200 UN2212 TRANSISTOR UNR2212 QR1301-04 UNR221300L TRANSISTOR R1120 ERDS1TJ474 1W 470K R1150 ERDS2FJ6R8 1/4W 6.8 R1151 ERDS2FJ562 1/4W 5.6K R1152 ERDS2FJ103 1/4W 10K...
Page 53 ZA1261 XTN3+8G SCREW...
Page 54: Lithium Battery
Ref. No. Part No. Part Name & Description Remarks REP3497E B7501 CR-2032/1GUF LITHIUM BATTERY C1502 F2A1E221A210 25V 220U C1503,04 F2A1A471A211 10V 470U C1505,06 F2A0J471A256 6.3V 470U C1507 ECJ1VB1C104K 16V 0.1U C1508 F2A0J470A012 6.3V 47U C1509 F2A1E4700048 25V 47U C1512 F2A1E4700048 25V 47U C1514 F2A1E4700048...
Page 55 Ref. No. Part No. Part Name & Description Remarks C3061 ECA0JM102 6.3V 1000U C3062 ECEA0JKS101 6.3V 100U C3063,64 ECEA0JKS331 6.3V 330U C3066 ECJ1VB1H102K 50V 1000P C3067 ECEA1HSN010 50V 1U C3068 ECEA0JKS220 6.3V 22U C3069 ECJ1VB1H103K 50V 0.01U C3070 ECJ1VB1H472K 50V 4700P C3071 ECJ1VB1H103K 50V 0.01U...
Page 56 Ref. No. Part No. Part Name & Description Remarks C4070 F2A1A101A206 10V 100U C4072 F2A1A101A206 10V 100U C4074 ECJ1VF1C104Z 16V 0.1U C4076-78 ECJ1VF1C104Z 16V 0.1U C4079,80 ECJ1VC1H330J 50V 33P C4082-85 ECJ2VC1H102J 50V 1000P C4901 F2A1A101A206 10V 100U C4902 ECJ1VF1C104Z 16V 0.1U C4903 F2A0J470A179 6.3V 47U...
Page 57 Ref. No. Part No. Part Name & Description Remarks DP7501 A2BD00000070 FL DISPLAY TUBE IC1502 C0DBEFG00002 IC1504 C0DBZGG00010 IC1505 C0DBZHG00012 IC1508 C0DBZHE00014 IC1509 C0DBZFG00012 IC1513 C0DBZHE00014 IC3002 C2BBFE000133 IC3003 C1AB00001735 IC3005 C9ZB00000377 IC4002 C0JBAR000285 IC4003 C0ABBB000118 IC4009 C0ABBB000118 IC4010 C0DBZJG00006 IC4011 C0DBZHG00012 IC4012...
Page 58 Ref. No. Part No. Part Name & Description Remarks LB1501-05 J0JHC0000032 COIL LB3001 VLP0323A601T COIL J0JCC0000103 LB3901-04 VLP0323A601T COIL J0JCC0000103 LB3908-18 VLP0323A601T COIL J0JCC0000103 LB4907-14 VLP0323A601T COIL J0JCC0000103 LB7402,03 J0JHC0000032 COIL LB7408 J0JHC0000032 COIL LB7508 G0ZZ00001936 COIL LB9701,02 J0JHC0000032 COIL LB9703,04 ERJ3GEY0R00V 1/16W 0...
Page 59 Ref. No. Part No. Part Name & Description Remarks R3002,03 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R3004 MCR03PZHJ561 1/16W 560 R3005 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R3006 ERJ3GEYJ101 1/16W 100 D0GB101JA002 R3007 ERJ3GEYJ102V 1/16W 1K R3008 MCR03PZHJ561 1/16W 560 R3009 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R3010 ERJ3GEYJ101...
Page 60 Ref. No. Part No. Part Name & Description Remarks R3077 ERJ3GEYJ102V 1/16W 1K R3080 ERJ3GEY0R00V 1/16W 0 R3084,85 ERJ3GEYJ912V 1/16W 9.1K R3086 ERJ3GEY0R00V 1/16W 0 R3087 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R3096 ERJ3GEYJ271V 1/16W 270 R3099 ERJ3GEYJ222V 1/16W 2.2K D0GB222JA002 R3100 ERJ3GEYJ330V 1/16W 33 D0GB330JA002...
Page 61 Ref. No. Part No. Part Name & Description Remarks R7418,19 ERG2SJ471E 2W 470 R7445 ERJ3RBD222V 1/16W 2.2K R7446 ERJ3RBD153 1/16W 15K R7447 ERJ3RBD102V 1/16W 1K R7448 ERJ3RBD222V 1/16W 2.2K R7451 ERJ3RBD133V 1/16W 13K R7452 ERJ3GEYJ681V 1/16W 680 D0GB681JA002 R7501 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R7502...
Page 62: Tuner Pack
Ref. No. Part No. Part Name & Description Remarks TU7401 ENGD6201D TUNER PACK W501-08 ERJ3GEY0R00V 1/16W 0 W510-20 ERJ3GEY0R00V 1/16W 0 W522-25 ERJ3GEY0R00V 1/16W 0 X3001 H0D800400016 CRYSTAL OSCILLATOR X7501 H0A327200082 CRYSTAL OSCILLATOR X7502 H0D419400020 CRYSTAL OSCILLATOR ZJ7401 VJR0978 EARTH ANGLE K9ZZ00000424 ZJ9701 VJR0978...
Page 63 Ref. No. Part No. Part Name & Description Remarks C37011 ECJ1VB1C104K 16V 0.1U C37012 EEE0JA470SR 6.3V 47U C37013 ECJ1VB1C104K 16V 0.1U C37014 ECJ2YB1A105K 10V 1U C37015 EEE0JA101SP 6.3V 100U C37025 ECJ1VB1C104K 16V 0.1U C37031 ECJ1XC1H180J 50V 18P ECJ1VC1H180J C37032 ECJ1VC1H330J 50V 33P C37033 ECJ1VB1C104K...
Page 64 Ref. No. Part No. Part Name & Description Remarks FL50016-21 F1H0J1050018 FILTER FL50023 F1H0J1050018 FILTER FL50025 F1H0J1050018 FILTER FL50028 F1H0J1050018 FILTER FP3501 K1MN40A00018 CONNECTOR(40P) IC3201 C3ABMG000103 IC3202 C1ZBZ0002277 IC3203 MN673744 IC3204,05 C0JBAB000474 IC3401 C3ABPJ000018 IC3402 MN85572 IC3501,02 C3ABQG000043 IC3503 MN88301 IC4402 C0ABBB000105 IC4403...
Page 65 Ref. No. Part No. Part Name & Description Remarks LB9001 J0JHC0000032 COIL LB9003 J0JHC0000045 COIL LB9004,05 J0JHC0000032 COIL LB9006 J0JHC0000045 COIL LB9008-11 J0JHC0000032 COIL LB9012 J0JHC0000045 COIL LB9020,21 VLP0323A601T COIL J0JCC0000103 LB9038 VLP0323A601T COIL J0JCC0000103 LB37001,02 J0JHC0000032 COIL LB37005 J0JHC0000032 COIL LB50001 J0JHC0000032...
Page 66 Ref. No. Part No. Part Name & Description Remarks R3404 ERJ3GEYJ220V 1/16W 22 R3406 ERJ3GEYJ220V 1/16W 22 R3415,16 ERJ3GEYJ220V 1/16W 22 R3423 ERJ3GEYJ220V 1/16W 22 R3425 ERJ3GEY0R00V 1/16W 0 R3427 ERJ3GEY0R00V 1/16W 0 R3503 ERJ3GEYJ220V 1/16W 22 R3504-06 ERJ3GEYJ330V 1/16W 33 D0GB330JA002 R3507,08 ERJ3GEYJ220V...
Page 67 Ref. No. Part No. Part Name & Description Remarks R6706 ERJ3GEYJ333V 1/16W 33K D0GB333JA002 R6707 ERJ3GEYJ104 1/16W 100K R6708 ERJ3GEY0R00V 1/16W 0 R6709-18 ERJ3GEYJ470V 1/16W 47 R6719 ERJ3GEYJ333V 1/16W 33K D0GB333JA002 R6720,21 ERJ3GEYJ470V 1/16W 47 R6722 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R6723-26 ERJ3GEYJ470V 1/16W 47...
Page 68 Ref. No. Part No. Part Name & Description Remarks R37060 ERJ3GEYJ220V 1/16W 22 R37061,62 ERJ3GEY0R00V 1/16W 0 R37063 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R37064-70 ERJ3GEY0R00V 1/16W 0 R37100 ERJ3GEYJ220V 1/16W 22 R37103 ERJ3GEYJ220V 1/16W 22 R37104-06 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R37109,10 ERJ3GEYJ101 1/16W 100 D0GB101JA002...
Page 69 Ref. No. Part No. Part Name & Description Remarks RX3201-04 D1H82204A024 RESISTOR-RESISTOR RX3205-08 D1H83304A024 RESISTOR-RESISTOR RX3209,10 D1H82204A024 RESISTOR-RESISTOR RX3213,14 D1H82204A024 RESISTOR-RESISTOR RX3501-07 D1H82204A024 RESISTOR-RESISTOR RX3508-23 D1H83304A024 RESISTOR-RESISTOR RX3524 D1H84734A024 RESISTOR-RESISTOR RX3525 D1H81034A024 RESISTOR-RESISTOR RX3526-29 D1H83304A024 RESISTOR-RESISTOR RX3530-33 D1H82204A024 RESISTOR-RESISTOR RX3534-38 D1H81034A024 RESISTOR-RESISTOR RX3650,51...
Page 70 Ref. No. Part No. Part Name & Description Remarks RX50017 D1H81034A024 RESISTOR-RESISTOR RX50018-25 D1H82204A024 RESISTOR-RESISTOR RX50026-29 D1H84704A024 RESISTOR-RESISTOR T37001 J0JBD0000043 TRANSFORMER X3202 H0J540500006 CRYSTAL OSCILLATOR X6001 H2D330500001 CRYSTAL OSCILLATOR X37001 H0J245500020 CRYSTAL OSCILLATOR H0J245500025 REP3528AB C7001 ECJ1VF1A105Z 10V 1U C7003 ECJ1VF1C104Z 16V 0.1U C7004...
Page 71 Ref. No. Part No. Part Name & Description Remarks S7802 EVQ11G07K SWITCH,REC S7803 EVQ11G07K SWITCH,CH-DOWN S7804 EVQ11G07K SWITCH,SKIP-R S7805 EVQ11G07K SWITCH,STOP S7808 EVQ11G07K SWITCH,CH-UP S7809 EVQ11G07K SWITCH,MODE S7810 EVQ11G07K SWITCH,ERASE S7811 EVQ11G07K SWITCH,TIME WARP S7812 EVQ11G07K SWITCH,PLAY S7815 EVQ11G07K SWITCH,SKIP-F S7816 EVQ11G07K SWITCH,OPEN/CLOSE...
Page 72: Schematic Diagram For Printing With A4
Ref. No. Part No. Part Name & Description Remarks R6807 ERJ3GEYJ473V 1/16W 47K D0GB473JA002 R6808 ERJ3GEYJ101 1/16W 100 D0GB101JA002 R6809 ERJ3GEYJ222V 1/16W 2.2K D0GB222JA002 R6810,11 ERJ3GEYJ220V 1/16W 22 R6812,13 ERJ3GEYJ223V 1/16W 22K D0GB223JA002 R6814 ERJ3GEYJ103V 1/16W 10K D0GB103JA002 R6815-18 ERJ3GEYJ223V 1/16W 22K D0GB223JA002 R6819...
Page 73 Location Map (REAR) (FRONT) Main P.C.B. (2/4 Section) DMR-E60PP (REP3497E)
Page 74 MAIN P.C.B. Location Map (REAR) (FRONT) Main P.C.B. (3/4 Section) DMR-E60PP (REP3497E)
Page 75 Location Map (REAR) (FRONT) Main P.C.B. (4/4 Section) DMR-E60PP (REP3497E)
Page 76 MAIN P.C.B. TL7506 LB3918 C3064 C4074 R3017 R4002 R7505 Integrated Circuit IC1502 TL7507 LB4907 C3066 C4076 R3018 R4003 R7509 IC1504 TL7538 LB4908 C3067 C4077 R3019 R4004 R7513 IC1505 LB4909 C3068 C4078 R3020 R4006 R7514 Connector IC1508 JK3901 LB4910 C3069 C4079 R3021 R4008 R7515...
Page 77 IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. C1304 10V220 IMPORTANT SAFETY NOTICE: COMPONENTS IDENTIFIED WITH THE MARK HAVE THE SPECIAL CHARACTERISTICS FOR SAFETY. WHEN REPLACING ANY OF THESE COMPONENTS.ONLY THE SAME TYPE. COLD DMR-E60PP Main Power Supply Schematic Diagram...
Page 78 V:Video I/O Section(Page: KEY IN3 A:Audio Main Section(Page: T:Timer Section(Page: BLIND OPEN(H) DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT Sub Power Supply Section PART NUMBER IS SHOWN IN THE PARTS LIST, (Main P.C.B. (1/5)) AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 79 SD & PC CARD P.C.B. (1/2) DMR-E60PP (COMPONENT SIDE) SD & PC CARD P.C.B. (1/2) (REP3540BA)
Page 80 SD & PC CARD P.C.B. (2/2) DMR-E60PP (FOIL SIDE) SD & PC CARD P.C.B. (2/2) (REP3540BA)
Page 81 PCD11 PCD11 PCD12 PCD12 PCD13 PCD13 PCD14 RX6817 RX6815 PCD14 47KX4 47KX4 PCD15 PCD15 SCLK SCLK SDAT1 SDAT1 SDAT3 SDAT3 CKA1 2 4 6 8 RX6802 RX6805 RX6808 RX6811 33X4 33X4 33X4 33X4 DMR-E60PP SD & PC Card Schematic Diagram...
Page 82 IC6802 IC6801 IC6805 IC6810 IC6806 C0JBAZ001166 C0JBAE000098 C0JBAZ001859 C0JBAZ001859 C0JBAZ000608 R6811 22 DAT0 SDAT1 DAT1 DAT2 R6808 R6802 C6815 R6812 R6823 0.01 C6812 0.01 RX6818 12KX4 DMR-E60PP DMR-E60PP SD & PC Card Schematic Diagram SD & PC Card Schematic Diagram...
Page 83 D1260 L1400 QR1301 C1153 C1406 R1201 R1405 D1271 L1401 QR1302 D1272 C1154 C1407 R1204 R1407 LB1122 Main Power Supply P.C.B. QR1303 D1273 R1206 R1408 LB1123 C1200 C1409 QR1304 D1305 C1201 C1413 R1207 R1409 LB1124 DMR-E60PP Main Power Supply P.C.B. (VEP01933B)
Page 84 IC1150 IC1200 IC1302 Ref No. MODE 13.6 -480 PLAY 13.6 -480 STOP 13.6 -490 IC1303 IC1401 Ref No. MODE PLAY STOP Ref No. IC1410 MODE -0.1 13.8 -1.6 -1.5 -1.5 -1.5 -0.1 13.8 13.7 13.7 PLAY 13.8 -1.7 -1.7 -1.7 -1.7 -0.1 13.9...
Page 85 X SW+13V P1102 PP1501 IC1302 (REG.+5V) DR+5V P1103 PP1503 PP1502 (TO DVD RAM DRIVE) VOUT ON(H) Q1201 QR1200 QR1302 PHOTO QR1303 COUPLER FROM TIMER SEC. JC DR P ON(H) (IC7501- P.SAVE(L) COLD FROM TIMER SEC. (IC7501- DMR-E60PP Power Supply Block Diagram...
Page 86 (REG. DC + 5V) ON(H) REG. DC + 5V QR4006,4007 P3503 P6801 (PSC 17) VOUT 19,20,54,55 ON/OFF T7501 FROM RTSC SEC. NPWRON IP7501 (POWER TRANS.) QR6801 (IC3503- UNREG+38V TO TU7401- DMR-E60PP DMR-E60PP Power Supply Power Supply Block Diagram Block Diagram...
Page 87 PSC 1. X SW+5.15V PSC 9. D+3.3V Ref. No. Pin. No. Schematic Name Ref. No. Pin. No. Schematic Name IC7501 24,98 Timer (Main) IC3201 1,7,13,25 AV Input (Digital) IC7504 38,44 IC7505 IC3202 7,12,19,25 30,37,42,48 PSC 2. JC REG.+5V IC3203 31,38,45 Ref.
Page 88 PSC 9. D+3.3V PSC 12. REG.ANA+3.3V Ref. No. Pin. No. Schematic Name Ref. No. Pin. No. Schematic Name IC50001 1,11,14,19 AV Decoder (Digital) 2,11,12,21 AV Input (Digital) IC3203 1,3,9,14 26,30 IC50002 27,43,49 IC3402 30 AV Encoder (Digital) 5,15,26,39 30,31,42,51 1394/DV (Digital) IC50003 IC37002 52,58,66,75...
Page 89 G:Glue Section(Page DV:1394 DV Section(Page DS:RTSC Section(Page MSA1 MSA2 MSA3 MSA4 MSA5 MSA6 MSA7 R6017 47 XAIWE DS DV G EN XMWE3 XMWE2 DS DV G AI EN XMRE DECSYSCLK XCS1 XCS5 XCS6 DMR-E60PP System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 90 XNMI 3.3KX4 VDD(D3.3V) VDD(S D1.8V) RX6007 33X4 VDD(S D1.8V) R6013 VDD(D3.3V) SYSCLK R6014 RX6008 33X4 D3.3V SD1.8V CL6001 X6001 R6010 R6011 R6015 H2D330500001 R6012 (33MHz) D3.3V DMR-E60PP DMR-E60PP System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S) System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 91 2 4 6 8 RX6045 RX6048 33X4 33X4 XFROMCS DMR-E60PP DMR-E60PP NOTE: DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S) System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S) FOR ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.
Page 92 X SW5.15V XT MUTE TO ANALOG AUDIO AUDIO MUTE(L) (QR4002,4005) IC7505 L123 SWIDE L1/L2/L3 DET 3 (IC3003- (RESET) X SW 5.15V RESET(L) EXT SYNC(H) TO/FROM EXT SYNC(H) (QR3011,Q3012) ANALOG VIDEO VIDEO MUTE(L) VIDEO MUTE(L) (IC3005- DMR-E60PP Timer Block Diagram FRONT(R)P.C.B.
Page 93 TL7507 0.01 0.01 0.01 R7547 C7535 2200 L123 SWIDE X7502 H0D419400020 (4.194MHz) VIDEO MUTE(L) EXT SYNC(H) XTMUTE R7536 4700 TL7504 R7541 R7540 XINTM R7543 C7539 XINTP 100P R7542 R7537 R7546 XMPREQ X SW 5.15V DMR-E60PP Timer Section(Main P.C.B. (5/5))Schematic Diagram(T)
Page 94 THIS DRAWING FOR ORDERING. THE CORRECT R7555 PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED X SW 5.15V SINCE THIS DRAWING WAS PREPARED. DMR-E60PP DMR-E60PP Timer Section(Main P.C.B. (5/5))Schematic Diagram(T) Timer Section(Main P.C.B. (5/5))Schematic Diagram(T)
Page 95 L2 IN CPNC 2SB1218A0L R3019 2SD1819A0L L2 IN CPNY (BUFFER) (EXT-SYNC(L)OUT) Q3005 2SD1819A0L R3058 R3060 R3030 VIDEO MUTE(L) (BUFFER) C3081 0.01 L2 C SDET C3067 50V1 Q3004 EXT SYNC(H) R3087 2SB1218A C3066 (BUFFER) 1000P DMR-E60PP Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V)
Page 96 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR (PROGRESSIVE) ORDERING. THE CORRECT PART NUMBER IS SHOWNIN THE PARTS LIST, AND MAY BE SLIGHTLYDIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP DMR-E60PP Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V) Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V)
Page 97 IC1502 IC1504 IC1505 Ref No. MODE PLAY STOP IC1508 IC1513 Ref No. IC1509 MODE PLAY STOP IC3002 Ref No. MODE PLAY STOP IC3002 Ref No. MODE PLAY STOP IC3002 Ref No. MODE PLAY STOP IC3003 Ref No. MODE PLAY STOP IC3003 Ref No.
Page 98 IC3005 Ref No. MODE PLAY STOP IC3005 Ref No. MODE PLAY STOP Ref No. IC4002 MODE 11.9 11.9 12.0 PLAY 11.9 11.9 12.0 STOP 11.9 11.9 12.0 IC4003 IC4009 Ref No. MODE 12.0 12.0 PLAY 12.0 12.0 STOP 12.0 12.0 IC4010 IC4011 IC4012...
Page 99 Q7502 Q7509 Q7510 Q7511 Ref No. MODE -1.2 -1.8 13.8 -25.3 -25.2 -25.3 -25.2 PLAY -1.2 -1.8 13.8 -25.4 -25.3 -25.3 -25.3 STOP -1.2 -1.8 13.9 -25.2 -25.2 -25.2 -25.2 QR3001 QR3002 QR3004 QR3005 QR3006 Ref No. MODE PLAY STOP QR3007 QR3009 QR3010...
Page 100 PP9701 Ref No. MODE PLAY STOP PP9701 Ref No. MODE PLAY STOP PP9702 Ref No. MODE PLAY STOP PP9702 Ref No. MODE PLAY STOP PP9703 Ref No. MODE -0.1 PLAY -0.1 STOP -0.1 PP9703 Ref No. MODE PLAY STOP...
Page 101: Interconnection Schematic Diagram
14 Schematic Diagram 14.1. Interconnection Schematic Diagram U/V TUNER P7001 P7501 PP9701 PS9001 CPNCIN DM CNPNCIN DM TU7401 N SW 5V N SW 5V DGND DGND KEYIN2(L) KEYIN2(L) V YIN DM V YIN DM KEYIN2(R) KEYIN2(R) DGND DGND KEYIN3(L) KEYIN3(L) CLAMP PULSE CLAMP PULSE KEYIN3(R)
Page 102: Dvd Ram Drive
INTRQ THE CORRECT PART NUMBER IS SHOWN P202 IN THE PARTS LIST, AND MAY BE DR 12V SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DR 5V CS0- CS0- DR 5V CS1- CS1- DR 12V DMR-E60PP Interconnection Schematic Diagram...
Page 103 14.2. Main Power Supply Schematic Diagram ( Main Power Supply P.C.B. ) P1101 ZA1103 ZA1104 K3GD9BB00001 K3GD9BB00001 K2AB2H000004 F1101 T1150 K5D162BK0005 G4D2A0000112 L1120 D1140 (POWER TRANSFORMER) SEE THE G0B123E00001 B0EBKT000002 LB1122 SERVICE MANUAL J0JKB0000003 D1110 C1143 C1121 ERZVGAD471 250V100 0.01 C1402 0.047 LB1120...
Page 104: Main Power Supply Schematic Diagram
IC1200 2400 uPC1093V (ERROR VOLTAGE DET.) TO P7801 FRONT(R) P.C.B. R1211 P1104 4700 ON(H) IC1303 C0DBZHE00014 LED WARP ON(H) (REG.+5.15V) BLIND OPEN(H) VOUT KEYIN1 KEYIN2 QR1200 KEYIN3 UNR2212 (SWITCH) X SW 5.15V C1304 10V220 DMR-E60PP Main Power Supply Schematic Diagram...
Page 105 14.3. Sub Power Supply Schematic Diagram (P) ( Main P.C.B. 1/5 ) TO P1102 MAIN POWER SUPPLY P.C.B. PP1501 LB1501 J0JHC0000032 D 1.8V D 1.8V LB1502 J0JHC0000032 D 3.3V D 3.3V LB1503 J0JHC0000032 X SW 5.15V LB1504 J0JHC0000032 X SW 5.9V LB1505 J0JHC0000032 X SW 13V IC1508...
Page 106: Sub Power Supply Section (Main P.c.b. (1/5)) Schematic Diagram(P)
(REG.ANA +5V) ON(H) C1528 POWER ON(H) C1512 25V47 DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT Sub Power Supply Section PART NUMBER IS SHOWN IN THE PARTS LIST, (Main P.C.B. (1/5)) AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 107 14.4. Main Net Schematic Diagram (M) ( Main P.C.B. 2/5 ) IIC DATA IIC CLK TO PS9003 UNREG DIGITAL P.C.B. (DIGITAL NET) PP9703 DGND JC REG UARTG2P TUNER UARTP2G CC LN21 TU VID CC FIELD QR7401 CC LN21 R7405 UNR521300L 2200 CC SCLK CC DATAO...
Page 108: Main Net Section(Main P.c.b. (2/5)) Schematic Diagram(M
V YIN DM DGND CPNCIN DM CPNCIN DM DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING.THE CORRECTPART Main Net Section(Main P.C.B. (2/5)) NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 109 14.5. Video I/O Schematic Diagram (V) ( Main P.C.B. 3/5 ) LINE LINE P:Sub Power Supply Section(Page: IN(R) IN(R) IN(L) IN(L) L3 IN L1 IN CPN L3 IN JK3901 M:Main Net Section(Page: K1U822B00001 V:Video I/O Section(Page: A:Audio Main Section(Page: T:Timer Section(Page: IIC CLK IIC DATA R3017...
Page 110: Video I/O Section(Main P.c.b. (3/5))Schematic Diagram(V)
L1/L2/L3 DET OUT C3086 0.01 C3093 0.01 VIDEO3 IN C4IN C/S DET3 VDD1 C3029 0.01 C3087 0.01 TL3001 C3051 QR3011 6V100 UN5113TW (EXT-SYNC(H) OUT) C3071 C3083 Q3012 0.01 0.01 2SD1819A0L (EXT-SYNC(L)OUT) R3030 C3081 0.01 R3087 DMR-E60PP Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V)
Page 111 G0C220JA0019 2SD1819A0L (BUFFER) L3021 L3022 C3047 C3046 Q3009 6.8u G0C120JA0019 R3047 100 0.01 6V47 L3016 2SB1218A G0C4R7JA0019 R3052 (BUFFER) C3074 C3014 C3075 R3053 R3051 2200 C3003 C3073 QR3005 UNR521100L QR3006 (PROGRESSIVE) UNR521300L (PROGRESSIVE) DMR-E60PP Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V)
Page 112 C3049 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWNIN THE PARTS LIST, AND MAY BE SLIGHTLYDIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP Video I/O Section(Main P.C.B. (3/5))Schematic Diagram(V)
Page 113 14.6. Audio Schematic Diagram (A) ( Main P.C.B. 4/5 ) AU +9V AU +9V C4037 50V10 R4052 68K L1 IN L C4038 50V10 R4053 68K L3 IN L C4039 50V10 R4054 68K L2 IN L R4013 18K C4043 0.1 C4028 R4037 R4040 R4042...
Page 114: Audio Main Section (Main P.c.b. (4/5)) Schematic Diagram(A)
R4093 (MUTE) (MUTE) R4074 47K R4080 820 C4064 25V47 R4081 820 DMR-E60PP C4083 C4085 Audio Main Section 1000P 1000P (Main P.C.B. (4/5)) E:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN Schematic Diagram(A) IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 115 14.7. Timer Schematic Diagram (T) ( Main P.C.B. 5/5 ) DP7501 A2BD00000070 P:Sub Power Supply Section(Page: M:Main Net Section(Page: V:Video I/O Section(Page: TL7501 A:Audio Main Section(Page: T:Timer Section(Page: KEYIN3 KEYIN2 TO P7001 FRONT(L)P.C.B. P7501 N SW 5V KEYIN2(L) KEYIN2(R) KEYIN3(L) KEYIN3(R) L2 IN(R) L7502...
Page 116: Timer Section(Main P.c.b. (5/5))Schematic Diagram(T)
R7558 100 GND(AD) REAL TIME CLK 5V(AD) PROG L KEYIN3 XMPREQ(TBUS) KEYIN2(L) JSUT CLOCK TL7506 C7535 R7547 2200 X7502 H0D419400020 (4.194MHz) R7536 4700 R7541 R7540 R7543 C7539 100P R7542 R7537 R7546 X SW 5.15V DMR-E60PP Timer Section(Main P.C.B. (5/5))Schematic Diagram(T)
Page 117 B7501 CR2032-1GUF C0ZBZ0000732 (FAN MOTOR DRIVE) BACK-UP BATTERY TL7502 R7557 C7586 X7501 16V47 H0A327200082 (32.768MHz) C7547 C7548 IC7505 IC7503 C0EBH0000263 C0EBF0000182 (RESET) (SYS PFAIL(H)OUT) QR7501 C7518 UNR521200L (SYS PFAIL(H)OUT) R7550 R7555 X SW 5.15V DMR-E60PP Timer Section(Main P.C.B. (5/5))Schematic Diagram(T)
Page 118 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP Timer Section(Main P.C.B. (5/5))Schematic Diagram(T)
Page 119 14.8. Digital Net Schematic Diagram (DN) ( Digital P.C.B. 1/8 ) TO PP9701 MAIN P.C.B. (MAIN NET) PS9001 CPNCIN DM DGND V YIN DM DGND CLAMP PULSE CLAMP DC Y GCA CONT DGND COUT DM DGND YOUT DM DGND RPROUT DM DGND BPBOUT DM FL9016...
Page 120 CC CLK CC FIELD CC LN21 UARTP2G UARTG2P DMR-E60PP RT NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN Digital Net Section(Digital P.C.B.(1/8)) Schematic Diagram(DN) AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 121 14.9. AV Input Schematic Diagram (AI) ( Digital P.C.B. 2/8 ) D3.3V ANA3.3V LB3203 J0JHC0000032 ADBCK1 LB4401 J0JGC0000020 R4418 47 CLK27A3 SETUP R3219 R3220 R3223 CLIP 5600 6800 Q3202 R3233 0 2SD1819A0L CPSVIN DM Q3201 CPNCIN DM (BUFFER) 2SB1218A0L Y GCA CONT R3222 C GCA CONT 100K...
Page 122 (CLOCK OUT) (VIDEO PROCESSOR) 22X4 R656ENC4 R656OUT4 R656ENC5 R656ENC6 R656OUT5 R656ENC7 R656OUT6 R3203 NTSC/PAL R656OUT7 C3208 6V22 FL3211 F1H0J1050018 LB3202 J0JHC0000032 LB3204 J0JHC0000032 C3205 IC3201 C3ABMG000103 (16bit/16M SDRAM) LB3201 J0JHC0000032 R4412 C3201 C3202 (Page DMR-E60PP AV Input Section(Digital P.C.B.(2/8)) Schematic Diagram(AI)
Page 123 R3218 22 VSS3 F1H0J1050018 SDRCLKIN VDD3 DT15 MODT15 DT14 MODT14 VSS3 DT13 MODT13 DT12 MODT12 VDD3 DT11 MODT11 DT10 MODT10 VSS3 MODT9 MODT8 VDD3 MODT7 MODT6 VSS3 MODT5 MODT4 VDD3 MODT3 MODT2 FL3212 F1H0J1050018 DMR-E60PP AV Input Section(Digital P.C.B.(2/8)) Schematic Diagram(AI)
Page 124 D1.8V FL3216 F1H0J1050018 MRWR MRWW DMR-E60PP AV Input Section (Digital P.C.B.(2/8)) NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN Schematic Diagram(AI) IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 125 14.10. AV Encoder Schematic Diagram (EN) ( Digital P.C.B. 3/8 ) D3.3V D1.8V DGND FL3406 FL3405 FL3404 FL3403 F1H0J1050018 F1H0J1050018 F1H0J1050018 F1H0J10500 FL3428 F1H0J1050018 ANA3.3V R656ENC7 R656ENC7 R656ENC6 R656ENC6 R656ENC5 R656ENC5 R656ENC4 R656ENC4 R656ENC3 R656ENC3 R656ENC2 R656ENC2 R656ENC1 R656ENC1 R656ENC0 R656ENC0 CLK27A1 R3403 0...
Page 126 MN85572 NMCAS (AV ENCODER) VDD(D3.3V) NMRAS MCLKIN NMCS VDD(D1.8V) NMWE VDD(D3.3V) R3423 22 MDQM MDQA27 MDQ27 MDQA26 MDQ26 VDD(D3.3V) MDQA25 MDQ25 MDQA24 MDQ24 VDD(D1.8V) MDQA23 MDQ23 MDQA22 MDQ22 VDD(D3.3V) MDQA21 MDQ21 MDQA20 MDQ20 DMR-E60PP AV Encoder Section(Digital P.C.B.(3/8)) Schematic Diagram(EN)
Page 127 D3.3V RA3401 RA3402 22X4 22X4 3 5 7 LB3402 FL3402 J0JHC0000032 F1H0J1050018 LB3401 FL3401 J0JHC0000032 F1H0J1050018 R3415 22 R3416 22 RA3407 RA3408 22X4 22X4 3 5 7 3 5 7 DMR-E60PP AV Encoder Section(Digital P.C.B.(3/8)) Schematic Diagram(EN)
Page 128 22X4 3 5 7 3 5 7 DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN AV Encoder Section(Digital P.C.B.(3/8)) IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 129 14.11. AV Decoder Schematic Diagram (AD) ( Digital P.C.B. 4/8 ) D 3.3V D 1.5V D GND FL10 F1H0J1050018 1 3 5 7 1 3 5 7 MSA1 MSA2 MSA3 MSA4 MSA5 MSA6 MSA7 SA10 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 SA11 SA12 SA13...
Page 130 DAC5OUT IREF1 2SB1218A0L AVDD3.3 COMP1 (BUFFER) DAC4OUT VREF DAC2OUT AVSS AVDD3.3 IREF2 COMP2 DAC1OUT PLLAVDD3.3 DAC3OUT PLLAVSS CL50006 FL17 F1H0J1050018 TCPOUT 2SB1218A0L (BUFFER) 1800 2SB1218A0L (BUFFER) 6V22 2SB1218A0L (BUFFER) J0JHC0000032 ANA3.3V D3.3V J-LINE DMR-E60PP AV Decoder Section(Digital P.C.B.(4/8)) Schematic Diagram(AD)
Page 131 F1H0J1050018 C26 6V47 F1H0J1050018 XTALIN DVSS XTALOUT CLK512FS1 VSS2 CLK512FS2 VDD2 VDD2 IC10 C0FBBK000035 CLK33M VSS2 (AUDIO D/A CONVERTER) F1H0J1050018 J0JHC0000032 ANA3.3V D3.3V J-LINE DMR-E60PP NOTE:DO NOT USE THE PART NUMBER IS AV Decoder Section(Digital P.C.B.(4/8))Schematic Diagram(AD) SINCE THIS DRAW...
Page 132 REF.NO.50000 SERIES J-LINE NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT DMR-E60PP PART NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED AV Decoder Section(Digital P.C.B.(4/8))Schematic Diagram(AD) SINCE THIS DRAWING WAS PREPARED.
Page 133 14.12. System Control Schematic Diagram (S) ( Digital P.C.B. 5/8 ) D 3.3V D3.3V S D1.8V SD1.8V XRESET DGND MD10 MD11 MD12 MD13 MD14 MD15 FL6001 F1H0J1050018 TO DIGITAL JIG P6001 XDIAG XDIAG XRESET 42 4 SBIO MSORX D 3.3V SBO0 MSOTX CLIP...
Page 134 MA10 XMBE0 MA13 SDCKE MA14 SDCLK XMCS0 XMRAS XMCAS XMWE XMBE0 DN:Digital Net Section(Page AI:AV Input Section(Page EN:AV Encoder Section(Page AD:AV Decoder Section(Page S:System Control Section(Page G:Glue Section(Page DV:1394 DV Section(Page DS:RTSC Section(Page DMR-E60PP System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 135 PIO16 R6007 RX6003 PIO15 3.3KX4 PIO14 PIO13 PIO12 PIO11 PIO10 XIRQ0 RX6004 XIRQ1 3.3KX4 XIRQ2 R6008 XIRQ3 XIRQ4 XIRQ5 XIRQ6 R6009 XIRQ7 RX6005 XNMI 3.3KX4 VDD(D3.3V) VDD(S D1.8V) RX6007 33X4 RX6008 33X4 D3.3V DMR-E60PP System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 136 (MAIN CPU) SA20 SA19 SA18 SA17 SA16 VDD(S D1.8V) VDD(D3.3V) SA15 SA14 SA13 SA12 SA11 SA10 VDD(S D1.8V) R6013 VDD(D3.3V) SYSCLK R6014 D3.3V SD1.8V CL6001 X6001 R6010 R6011 R6015 H2D330500001 R6012 (33MHz) DMR-E60PP am(S) System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 137 33X4 RX6040 33X4 48 47 46 45 35 34 31 30 27 26 IC6007 C0JBAZ001475 (ADDRESS BUFFER) 2 4 6 8 2 4 6 8 2 4 6 8 RX6045 RX6048 33X4 33X4 DMR-E60PP System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S)
Page 138 31 30 27 26 XRSTOUT IC6006 C3CBKD000119 (8Mbit LOADER) GSYSCLK XFROMCS DMR-E60PP NOTE: DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM am(S) System Control Section(Digital P.C.B.(5/8)) Schematic Diagram(S) FOR ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.
Page 139 14.13. Glue Schematic Diagram (G) ( Digital P.C.B. 6/8 ) D3.3V DGND R6746 0 ENCMCK2 ENCMCK1 FL6701 CL6797 CL6796 CL6795 F1H0J1050018 IC6702 DVMCKO C0JBAB000474 DVMCKO DVBCKO DVBCKO (CLOCK OUT) DVLRCKO RX6746 DVLRCKO 10KX4 DVDATAO DVDATAO OLRCK OLRCK OBCK OBCK OMCK RX6705 OMCK 10KX4...
Page 140 2 4 6 8 2 4 6 8 2 4 6 8 7 5 3 1 7 5 3 1 7 5 3 1 7 5 3 1 2 4 6 8 7 5 3 1 DMR-E60PP Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G)
Page 141 10KX4 RX6743 3.3KX4 D3.3V CL6814 CL6817 CL6816 RX6721 CL6815 47X4 RX6744 3.3KX4 R6723 47 RX6732 47X4 RX6735 47X4 RX6736 47X4 RX6740 33KX4 RX6737 47X4 DN:D RX6739 33KX4 EN:A S:Sy DV:1 RX6738 47X4 RX6733 33KX4 DMR-E60PP Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G)
Page 142 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G)
Page 143 14.14. 1394 DV Schematic Diagram (DV) (Digital P.C.B. 7/8) & DV JACK Schematic Dia D3.3V D1.8V CLK27A6 ANA3.3V F1H0J1050018 RX15 10KX4 DMA0 DMA1 DMA2 DMA3 RX16 10KX4 DMA4 DMA5 DMA6 XRSTOUT DMA7 RX17 R104 10K 10KX4 DMA8 DMA9 R105 10K DMA10 DMA11 RX18...
Page 144 PTEST1 PTEST0 VDD(D1.8V) TIN0 TIN1 TIN2 TIN3 TIN4 TIN5 TIN6 VDD(D3.3V) MSA1 MSA2 MSA3 MSA4 VSS33 MSA5 MSA6 MSA7 7 5 3 7 5 3 8 6 4 2 8 6 4 2 DMR-E60PP 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV)
Page 145 FSVCC CGAIN (VCO) R110 FSFOADJ CGBFOUT R28 18K FSGND CGBFIN FSCLK CGSEL C13 0.1 IC11 FSGND 27GND C0JBAA000102 (VCO) 27CK R21 1K R22 10K FL14 F1H0J1050018 J0JHC0000032 R63 10K C1BB00000699 (SAMPLE RATE CONVERTER) DMR-E60PP 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV)
Page 146 EN:AV Encoder Section(Page S:System Control Section(Page G:Glue Section(Page R656DD0 R656DD0 R656DD1 R656DD1 DV:1394 DV Section(Page DS:RTSC Section(Page R656DD2 R656DD2 R656DD3 R656DD3 R656DD4 R656DD4 R656DD5 R656DD5 R656DD6 R656DD6 R656DD7 R656DD7 R656DVSW R656DVSW REF NO.37000 SERIES DMR-E60PP m(DV) 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV)
Page 147 14.15. Real Time Stream Control (RTSC) Schematic Diagram (DS) (Digital P.C.B. 8/8) D3.3V D2.5V DN:Digital Net Section(Page AI:AV Input Section(Page EN:AV Encoder Section(Page AD:AV Decoder Section(Page S:System Control Section(Page G:Glue Section(Page DV:1394 DV Section(Page FL3503 F1H0J1050018 DS:RTSC Section(Page RCLKI RCLKI CDACK CDACK CDREADY...
Page 148 MAB2 MADR2 MAB5 MADR5 MAB3 MADR3 MAB3 MAB4 MADR4 MAB2 MAB1 MAB0 R3503 22 MAB10 MAB6 MADR6 BA1S D BA0S D XCS1 D XRAS D XCAS D XWE D DQL D DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 149 B3STRB B3STRB HNCS HNRE FL3507 HNWE0 F1H0J1050018 HNWE1 VDD(D2.5V) HNDK MSA1 HADR1 VDD(D3.3V) MSA2 HADR2 MSA3 HADR3 MSA4 HADR4 MSA5 HADR5 MSA6 HADR6 MSA7 HADR7 HADR8 HADR9 SA10 HADR10 FL3509 F1H0J1050018 DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 150 VDD(D2.5V) DDMARQ R3528 33 NIOW C DNIOWR NIOR C DNIORD DDA1 R3529 33 RX3523 33X4 NCD2 NWE C NOE C PCA1 RX3517 33X4 PCA0 PCA2 NCE1 NCE2 RESPC R3515 DMR-E60PP ic Diagram(DS) Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 151 CKA43 RX3516 33X4 SDAT3 SDAT3 CKA17 SDAT2 SDAT2 LB3501 SDAT1 SDAT1 J0JHC000 SDAT0 SDAT0 R3512 33 CKA19 LB3502 J0JHC000 R3511 33 SCMD SCMD R3510 33 SDCK SDCK R3509 33 R3544 47K DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 152 DV:1394 DV Section(Page R3541 C3502 5600 0.01 DS:RTSC Section(Page RX3525 RX3534 10X4 10X4 LB3501 J0JHC0000032 X SW 5.9V LB3502 J0JHC0000045 R3538 R3533 QR3501 QR3503 UNR521300L UNR521300L (RESET) (RESET) R3547 XDAVINT DMR-E60PP m(DS) Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 153: Sd & Pc Card Schematic Diagram
14.16. SD & PC Card Schematic Diagram LB6801 J0JHC0000032 CKA54 LB6802 J0JHC0000045 CKA52 LB6803 J0JHC0000045 CKA51 C6803 C6804 C6805 C6813 16V47 TO P3503 DIGITAL P.C.B. (RTSC SECTION) P6801 PCA0 PCA0 PCA2 PCA2 PCA4 PCA4 PCA6 PCA6 PCA8 PCA8 STSCHG NREG NREG RESET RESET...
Page 154 RX6810 33X4 33X4 33X4 33X4 FL6801 F1H0J1050018 IC6804 C0JBAZ001988 (WORKING MEMORY) FL6802 F1H0J1050018 RX6816 RX6814 47KX4 47KX4 RX6817 RX6815 47KX4 47KX4 2 4 6 8 RX6802 RX6805 RX6808 RX6811 33X4 33X4 33X4 33X4 DMR-E60PP SD & PC Card Schematic Diagram...
Page 155 2 4 6 8 FL6803 RX6803 RX6806 RX6809 RX6812 F1H0J1050018 33X4 33X4 33X4 33X4 1 3 5 7 1 3 5 7 C6801 C6806 C681 R6801 R6824 IC6802 IC6801 IC6805 IC6810 C0JBAZ001166 C0JBAE000098 C0JBAZ001859 C0JBAZ R6802 DMR-E60PP SD & PC Card Schematic Diagram...
Page 156 SDAT3 SCMD SDAT0 TO SD CARD P6803 DAT3 R6828 12K R6810 22 3.3V SCLK IC6810 IC6806 C0JBAZ001859 C0JBAZ000608 R6811 22 DAT0 SDAT1 DAT1 DAT2 R6808 C6815 R6812 R6823 0.01 C6812 0.01 RX6818 12KX4 DMR-E60PP SD & PC Card Schematic Diagram...
Page 157 14.17. Front (L) Schematic Diagram TO P7501 MAIN P.C.B. (TIMER SECTION) P7001 CPN 2Y IN CPN 2C IN LINE 2V IN L2 C SDET L2 IN(L) L2 IN(R) KEYIN3(R) KEYIN3(L) KEYIN2(R) KEYIN2(L) N SW 5V POWER R7011 S7003 EVQ11G07K IR7001 PNA4618M13VT (REMOTE CON.SENSOR) K7002...
Page 158 C7004 0.01 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE DMR-E60PP SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. Front (L) Schematic Diagram...
Page 159: Front (R) Schematic Diagram
14.18. Front (R) Schematic Diagram TRAY S7801 K0L1BA000056 TO P1104 MAIN POWER SUPPLY P.C.B. P7801 LED WARP ON(H) BLIND OPEN(H) KEYIN1 KEYIN2 KEYIN3 X SW 5.15V CH-UP SKIP-F R7801 R7807 S7802 S7808 S7815 1200 1200 EVQ11G07K EVQ11G07K EVQ11G07K CH-DOWN MODE OPEN-CLOSE R7802 R7808...
Page 160 EVQ11G07K NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP Front (R) Schematic Diagram...
Page 161 WF No. PP9701-15 (REC/PLAY) WF No. PP9701-16 (REC/PLAY) WF No. PP9701-18 (REC/PLAY) (20usec/div) (20usec/div) (20usec/div) 0.6Vp-p 1.1Vp-p 0.6Vp-p WF No. PP9701-20 (REC/PLAY) WF No. PP9701-22 (REC/PLAY) WF No. PP9701-28 (REC/PLAY) (20usec/div) (20usec/div) 1.0Vp-p 0.7Vp-p (20usec/div) 1.9Vp-p WF No. PP9702-12 (REC/PLAY) WF No.
Page 162 C4034 25V47 (MUTE) C4064 R4045 R4047 R4057 25V47 R4081 820 QR4003 7500 DMR-E60PP UNR521100L XDMUTE C4083 C4085 (MUTE) 1000P Audio Main Section 1000P (Main P.C.B. (4/5)) NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN Schematic Diagram(A) IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 163 PS9002 PP9702 MIX L OUT DM MIX L OUT2 FROM OUT2-L DIGITAL AUDIO MIX R OUT1 OUT1-R PS9002 PP9702 MIX R OUT DM MIX R OUT2 OUT2-R JK3903 DIGITAL AUDIO OUT (PCM/BITSTREAM) PS9002 PP9702 IECOUT OPTICAL DMR-E60PP Analog Audio Block Diagram...
Page 164 DECIEC DMIX SRCK 1800 SA17 LRCK ACLKSEL CLK54A2 ENCMCK1 ENCMCK 2SB1218A0L CLK27A2 (BUFFER) CLK27A1 FL14 CLK27O1 F1H0J1050018 6V22 8 6 4 2 2SB1218A0L CLK27A6 CLK27A8 (BUFFER) CLK27A3 J0JHC0000032 ANA3.3V D3.3V MCK512 J-LINE J-LINE DMR-E60PP AV Decoder Section(Digital P.C.B.(4/8)) Schematic Diagram(AD)
Page 165 D3.3V J-LINE J-LINE REF.NO.50000 SERIES DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT DMR-E60PP PART NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED AV Decoder Section(Digital P.C.B.(4/8))Schematic Diagram(AD) AV Decoder Section(Digital P.C.B.(4/8))Schematic Diagram(AD)
Page 166 MSD31 MSA1 MSA2 MSA3 MSA4 MSA5 DN:Digital Net Section(Page AI:AV Input Section(Page MSA6 MSA7 EN:AV Encoder Section(Page AD:AV Decoder Section(Page XAIWE XMRE S:System Control Section(Page G:Glue Section(Page XA1OFCS DV:1394 DV Section(Page DS:RTSC Section(Page DMR-E60PP AV Input Section(Digital P.C.B.(2/8)) Schematic Diagram(AI)
Page 167 (Digital P.C.B.(2/8)) NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN DMR-E60PP AV Input Section(Digital P.C.B.(2/8)) Schematic Diagram(AI) Schematic Diagram(AI) IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 168 P7001 P7501 L2 IN CPNC C2 IN V YIN DM PP9701 PS9003 Y/V OUT P7001 P7501 L2 IN CPNY CLAMP DC PP9701 PS9003 Y2 IN CLAMP DC P7001 P7501 L2 C SDET S-VIDEO C/S DET2 DMR-E60PP Analog Video Block Diagram...
Page 169 Ref.No.37000 SERIES DATA(MSD16-MSD31)/ADDRESS BUS LINE(MSA1-MSA7) RTSC Ref.No.3500 SERIES Main Net Ref.No.9700/7400 SERIES Digital P.C.B.connect circuit PP9701,PP9702,PP9703 Sub Power Supply Ref.No.1500 SERIES DMR-E60PP Main P.C.B. Video I/O Main Ref.No.3000/3900/4900 SERIES Digital Block Diagram Audio Main Ref.No.4000 SERIES DATA(SD16-SD31)/ADDRESS BUS LINE(SA0-SA25) Timer Ref.No.7500 SERIES...
Page 170 IC Pin Terminal Chart (TC 1 - TC 6 ) IC Pin Terminal Chart (TC 7, TC 8, TC 9, TC 15, TC 16, TC 21, TC 22, TC 23 ) IC3203 / VAD CON IC3202 / V-PROCESSOR IC3402/AV ENC IC3202/V-PROCESSOR IC50003/AV DEC IC6004 / MAIN CPU...
Page 171 SD16 - SD31 DATA BUS LINE (TC20-2, TC17-2, TC19-2 ) SA0 - SA25 ADDRESS BUS LINE (TC20-1, TC12-3, TC17-1, TC18, TC19-1, TC25, 27) 20-1 12-3 17-1 19-1 20-2 17-2 19-2 IC6004/MAIN CPU IC3503 / RTSC IC6701/GLUE IC6007 / BUFFER IC6006 / LOADER IC50003 / AVDEC IC37001 / DV CODEC IC6004 / MAIN CPU...
Page 172 OVER VIEW *IC6703 is not supplied in the form of an individual part. When replacing, be sure to replace the Digital P.C.B. and not IC6703 singly. DIGITAL P.C.B. (1/2) DMR-E60PP (COMPONENT SIDE) DIGITAL P.C.B. (1/2) (REP3543B)
Page 173 DV JACK P.C.B. OVER VIEW DIGITAL P.C.B. (2/2) DMR-E60PP (FOIL SIDE) DV JACK P.C.B. (REP3540AB) DIGITAL P.C.B. (2/2) (REP3543B)
Page 174 DIGITAL P.C.B. Integrated Circuit CKA25 F CKC36 F CKE9016 F CL3603 F CL6814 F LB50003 F FL50007 C C37031 F R3534 F R6739 F R50004 C RX3507 F RX6707 IC3201 C CKA26 F CKC37 F CKE9017 F CL3604 F CL6815 F LB50004 F FL50008 F C37032...
Page 175 CC LN21 UARTP2G UARTG2P DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN Digital Net Section(Digital P.C.B.(1/8)) Schematic Diagram(DN) IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 176 BA0S D DGND 33X4 XCS1 D MSD19 HDAT3 XRAS D MSD18 HDAT2 XCAS D MSD17 HDAT1 XWE D XDAVCS MSD16 HDAT0 DQL D XMRE XMWE2 XMWE3 XDAVDK R3514 XRSTOUT R3517 DAVSYSCLK DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 177 HADR10 DDA1 R3529 33 RX3523 33X4 NCD2 NWE C NOE C PCA1 RX3517 33X4 PCA0 FL3509 F1H0J1050018 PCA2 NCE1 NCE2 RESPC R3515 DMR-E60PP DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS) Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 178 R3511 33 SCMD SCMD R3538 R3533 R3510 33 SDCK SDCK R3509 33 QR3501 QR3503 UNR521300L UNR521300L (RESET) (RESET) R3547 R3544 47K XDAVINT DMR-E60PP DMR-E60PP Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS) Real Time Stream Control(RTSC) Section(Digital P.C.B.(8/8)) Schematic Diagram(DS)
Page 179 (GLUE) Glue Ref.No.6700 SERIES 1394 DV Ref.No.37000 SERIES Mini boot RTSC Ref.No.3500 SERIES Firm ware Main Net Ref.No.9700/7400 SERIES WORKING DMR-E60PP Model information Audio EE Delay Digital P.C.B.connect circuit PP9701,PP9702,PP9703 16bit MEMORY U/H/F Error MP3 Playback MAIN CPU LOADER BUFFER...
Page 180 MSA3 D1.8V 7 5 3 7 5 3 MSA4 MSA4 F1H0J1050018 MSA5 MSA5 MSA6 MSA6 8 6 4 2 8 6 4 2 MSA7 MSA7 SA10 SA10 SA11 SA11 SA12 SA12 SA13 SA13 DMR-E60PP 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV)
Page 181 R656DD0 R656DD0 R656DD1 R656DD1 DV:1394 DV Section(Page DS:RTSC Section(Page R656DD2 R656DD2 R656DD3 R656DD3 R656DD4 R656DD4 R656DD5 R656DD5 R656DD6 R656DD6 R656DD7 R656DD7 R656DVSW R656DVSW REF NO.37000 SERIES DMR-E60PP DMR-E60PP 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV) 1394 DV Section(Digital P.C.B.(7/8)) Schematic Diagram(DV)
Page 182 HD13 VDD(D3.3V) MSD30 MSD30 MDQA21 MSD30 HD14 MDQ21 MSD31 MSD31 MDQA20 MSD31 HD15 MDQ20 FL3421 F1H0J1050018 D1.8V FL3409 F1H0J1050018 D3.3V MSA1 MSA1 MSA2 MSA2 MSA3 MSA3 MSA4 MSA4 MSA5 MSA5 XIRQ6 XMRE DMR-E60PP XMWE3 AV Encoder Section(Digital P.C.B.(3/8)) Schematic Diagram(EN)
Page 183 22X4 22X4 3 5 7 3 5 7 3 5 7 DMR-E60PP DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERRING.THE CORRECT PART NUMBER IS SHOWN AV Encoder Section(Digital P.C.B.(3/8)) AV Encoder Section(Digital P.C.B.(3/8)) IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 184 FRONT (L) P.C.B. DMR-E60PP FRONT (L) P.C.B. (REP3528AB)
Page 185 FRONT (R) P.C.B. DMR-E60PP FRONT (R) P.C.B. (REP3528BA)
Page 186 C7001 ERJ3GEY0R00V NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE DMR-E60PP SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. Front (L) Schematic Diagram...
Page 187 EVQ11G07K NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP Front (R) Schematic Diagram...
Page 188 QR7801 Ref No. MODE PLAY STOP...
Page 189 7 5 3 1 7 5 3 1 2 4 6 8 7 5 3 1 4.7KX4 MSA3 MSA4 R6719 33K R6749 MSA5 3300 MSA6 RX6710 MSA7 47X4 SA23 SA24 SA25 SA22 RX6749 4.7KX4 DMR-E60PP Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G)
Page 190 NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING. THE CORRECT PART NUMBER IS SHOWN IN THE PARTS LIST, AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED. DMR-E60PP DMR-E60PP Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G) Glue Section(Digital P.C.B.(6/8)) Schematic Diagram(G)
Page 191 TPA- TPA+ TPA+ SINCE THIS DRAWING WAS PREPARED. TPB+ X SW 5.15V TPB- TPA- TPA- DR 5V CS0- CS0- DR 5V TPB+ TPB+ CS1- CS1- TPB- TPB- DV JACK P.C.B. MAIN POWER SUPPLY DR 12V DMR-E60PP P.C.B. Interconnection Schematic Diagram...
Page 192 DGND PRGSEL(H) CPNCIN DM CPNCIN DM DMR-E60PP NOTE:DO NOT USE THE PART NUMBER SHOWN ON THIS DRAWING FOR ORDERING.THE CORRECTPART Main Net Section(Main P.C.B. (2/5)) NUMBER IS SHOWN IN THE PARTS LIST,AND MAY BE SLIGHTLY DIFFERNT OR AMENDED SINCE THIS DRAWING WAS PREPARED.
Page 193 Location Map (REAR) (FRONT) Main P.C.B. (1/4 Section) DMR-E60PP (REP3497E)

Panasonic DMR-E60PP Service Manual

Quick Links

Related Manuals for Panasonic DMR-E60PP

Summary of Contents for Panasonic DMR-E60PP

Table of Contents