Sony CDX-R30M Service Manual
Fm/am compact discplayer
Hide thumbs
Also See for CDX-R30M:
- Operating instructions manual (72 pages) ,
- Installation/connections (2 pages) ,
- Specification sheet (2 pages)
Table of Contents
Advertisement
SERVICE MANUAL
Ver. 1.1 2005.07
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
CDX-R3310:
87.5 – 107.9 MHz
CDX-R30M/R3410/R3410S:
87.5 – 108.0 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
FM tuning interval
50 kHz/200 kHz switchable
(CDX-R30M/R3410/R3410S)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Sony Corporation
9-879-386-02
2005G04-1
e Vehicle Group
© 2005. 07
Published by Sony Engineering Corporation
CDX-R30M/R3310/
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
SPECIFICATIONS
AM
Tuning range
AM tuning interval
Antenna terminal
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
Power amplifier section
Outputs
Speaker impedance
Maximum power output 52 W × 4 (at 4 ohms)
General
Outputs
Inputs
FM/AM COMPACT DISC PLAYER
R3410/R3410S
US Model
Canadian Model
AEP Model
UK Model
E Model
CDX-R3410/R3410S
NEW
MG-611TA-186//Q
KSS1000E
CDX-R3310:
530 – 1,710 kHz
CDX-R30M/R3410/R3410S:
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
9 kHz/10 kHz switchable
(CDX-R30M/R3410/R3410S)
External antenna connector
30 µV
Speaker outputs
(sure seal connectors)
4 – 8 ohms
Audio outputs terminal
(sub/rear switchable)
Power antenna relay control terminal
Power amplifier control terminal
BUS control input terminal
BUS audio input terminal
Remote controller input terminal
Antenna input terminal
– Continued on next page –
CDX-R30M
CDX-R3310
CDX-R30M
1
Advertisement
Table of Contents
Related Manuals for Sony CDX-R30M
Summary of Contents for Sony CDX-R30M
- Page 1 30 – 15,000 Hz BUS audio input terminal Remote controller input terminal Antenna input terminal – Continued on next page – FM/AM COMPACT DISC PLAYER Sony Corporation 9-879-386-02 2005G04-1 e Vehicle Group © 2005. 07 Published by Sony Engineering Corporation...
- Page 2 Card remote commander RM-X151 US and foreign patents licensed from Dolby Laboratories. optical pick-up Note This unit cannot be connected to a digital preamplifier or an equalizer which is Sony BUS system compatible. Design and specifications are subject to change without notice.
- Page 3 CDX-R30M/R3310/R3410/R3410S • CD Playback: UNLEADED SOLDER You can play CD-DA (also containing CD TEXT* ), CD-R/CD- Boards requiring use of unleaded solder are printed with the lead RW (MP3 files also containing Multi Session and ATRAC CD free mark (LF) indicating the solder contains no lead.
-
Page 4: Table Of Contents
CDX-R30M/R3310/R3410/R3410S TABLE OF CONTENTS 1. GENERAL Location of Controls ..............5 Connections ................6 2. DISASSEMBLY 2-1. Sub Panel Assy (CD) ............10 2-2. CD Mechanism Block ............10 2-3. Main Board ............... 11 2-4. Chassis (T) Sub Assy ............11 2-5. -
Page 5: General
– “Replacing the lithium battery of the card remote n Frequency select switch (located on the commander” on page 14. bottom of the unit) (CDX-R30M only) See ìF requency select switchî i n the supplied installation/connections manual. o Number buttons Radio: To receive stored stations (press);... -
Page 6: Connections
CDX-R30M/R3310/R3410/R3410S • CONNECTIONS • CDX-R30M/R3310 Connection example (2) Notes (2- A ) • Be sure to connect the ground lead before connecting the amplifi er. • The alarm will only sound if the built-in amplifi er is used. AUDIO OUT FRONT... - Page 7 CDX-R30M/R3310/R3410/R3410S • CDX-R30M/R3310 Source selector (not supplied) Supplied with the CD/MD changer Sélecteur de source Fourni avec le changeur de CD/MD (non fourni) XA-C30 Supplied with XA-C30 Fourni avec le XA-C30 AUDIO OUT REMOTE FRONT BUS AUDIO IN from car antenna à...
- Page 8 CDX-R30M/R3310/R3410/R3410S • CDX-R3410/R3410S Connection diagram (3) Diagrama de conexión (3) 1 To a metal surface of the car 1 A una superfi cie metálica del automóvil First connect the black earth lead, then connect the yellow Conecte primero el cable de conexión a masa negro, and red power input leads.
-
Page 9: Disassembly
CDX-R30M/R3310/R3410/R3410S SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. 2-1. SUB PANEL ASSY (Page 10) 2-2. CD MECHANISM BLOCK (Page 10) 2-10. SERVO BOARD 2-3. MAIN BOARD 2-4. CHASSIS (T) SUB ASSY (Page 14) -
Page 10: Sub Panel Assy (Cd)
CDX-R30M/R3310/R3410/R3410S Note : Follow the disassembly procedure in the numerical order given. 2-1. SUB PANEL ASSY (CD) 3 two claws 2 two claws 1 two screws (+PTT 2.6 x 6) 4 sub panel assy 2-2. CD MECHANISM BLOCK 7 bracket (CD) -
Page 11: Main Board
CDX-R30M/R3310/R3410/R3410S 2-3. MAIN BOARD 1 three screws (+BTT 2.6 x 5) 2 two screws (+PTT 2.6 x 8) 3 MAIN board 4 insulating sheet 2-4. CHASSIS (T) SUB ASSY 4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2) -
Page 12: Roller Arm Assy
CDX-R30M/R3310/R3410/R3410S 2-5. ROLLER ARM ASSY 3 washer 5 roller arm assy 4 gear (RA1) 2 spring (RAR) 1 spring (RAL) 2-6. CHASSIS (OP) ASSY qa chassis (OP) assy 0 coil spring (damper) lever (D) 4 washer 1 CN1 (16P) 9 two coil springs (damper) -
Page 13: Optical Pick-Up
CDX-R30M/R3310/R3410/R3410S 2-7. OPTICAL PICK-UP 2 chucking arm sub assy 5 claw 1 tension coil spring (CHKG) 7 optical pick-up 6 main shaft 4 rack (SL) 3 screw (+B 1.4 x 5) 2-8. SL MOTOR ASSY (M902) 1 screw (+P 1.4 x 1.8) -
Page 14: Le Motor Assy (M903)
CDX-R30M/R3310/R3410/R3410S 2-9. LE MOTOR ASSY (M903) 8 screw 0 gear (LE) assy (+M 1.7 x 2.5) 9 bearing (LEB-N) 2 washer qa screw (+M 1.7 x 2.5) qf two toothed lock screws 3 gear (LE1) (+M 1.4 ) lever (D) -
Page 15: Diagrams
CDX-R30M/R3310/R3410/R3410S SECTION 3 DIAGRAMS 3-1. BLOCK DIAGRAM — CD SECTION — • R-ch is omitted due to same as L-ch. • Signal Path : CD PLAY DETECTOR MAIN FPI2 CD-L AGCI RFEQO SECTION RFDCI RFRPI (Page 16) R-CH FNI2 FPI1... -
Page 16: Block Diagram -Main Section
CDX-R30M/R3310/R3410/R3410S 3-2. BLOCK DIAGRAM — MAIN SECTION — ELECTRONIC VOLUME IC401 BUS LCH AUDIO IN BUS RCH R-CH AUX IN R-CH CD-L 9 CD LCH SECTION OUT SUB L (Page 15) R-CH 8 CD RCH REAR PJ330 OUT SUB R... -
Page 17: Block Diagram -Display Section
CDX-R30M/R3310/R3410/R3410S 3-3. BLOCK DIAGRAM — DISPLAY SECTION — 3-4. CIRCUIT BOARDS LOCATION SYSTEM CONTROL LCD DRIVER IC501 (3/3) IC901 SERVO board KEY MATRIX KEYIN0 SENSOR board LCDSO DATA S900-908, 910-922 LCDCKO SEG4 KEYIN1 LCDCE SEG51 • LCD901 KEY ACK D501... - Page 18 CDX-R30M/R3310/R3410/R3410S • WAVEFORMS • NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS THIS NOTE IS COMMON FOR PRINTED WIRING — SERVO BOARD — BOARDS AND SCHEMATIC DIAGRAMS. (CD PLAY) (In addition to this, the necessary note is printed in each block.)
-
Page 19: Printed Wiring Boards -Cd Mechanism Section
CDX-R30M/R3310/R3410/R3410S 3-5. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 17 for Circuit Boards Location. : Uses unleaded solder. 1-689-230- • Semiconductor Location 1-864-901- 1-864-901- Ref. No. Location B-11 MAIN BOARD CNP301 (Page 22) CDX-R30M/R3310/R3410/R3410S... -
Page 20: Schematic Diagram -Cd Mechanism Section (1/2)
CDX-R30M/R3310/R3410/R3410S • Refer to page 18 for Waveforms. 3-6. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 28 for IC Block Diagrams. IC B/D C102 TP25 TP26 TP27 TP93 TP29 R125 R126 R127 R128 R113 TP101... -
Page 21: Schematic Diagram -Cd Mechanism Section (2/2)
CDX-R30M/R3310/R3410/R3410S • Refer to page 18 for Waveform. • Refer to page 28 for IC Block Diagram. 3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 31 for IC Pin Description. (Page 20) (Page 25) TP74... -
Page 22: Printed Wiring Board -Main Section
CDX-R30M/R3310/R3410/R3410S 3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 17 for Circuit Boards Location. : Uses unleaded solder. R30M/R3310 CN601 JC12 CN580 C484 C474 C444 C434 C330 C331 C774 C776 C775 JW144 JW154 C751 FU601 R472... -
Page 23: Schematic Diagram -Main Section (1/3)
CDX-R30M/R3310/R3410/R3410S • Refer to page 18 for Waveform. 3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 28 for IC Block Diagrams. J330 C330 C331 C484 C474 C444 C434 C403 R332 R330 JC12 C402 R333 R331 R335... -
Page 24: Schematic Diagram -Main Section (2/3)
CDX-R30M/R3310/R3410/R3410S 3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 30 for IC Block Diagram. C775 C765 C764 C774 C776 C751 D751 C752 D752 C750 D753 IC B/D D754 JC754 D755 JC755 D756 IC750 D757 CN601 D758... -
Page 25: Schematic Diagram -Main Section (3/3)
CDX-R30M/R3310/R3410/R3410S • Refer to page 18 for Waveforms. • Refer to page 29 for IC Block Diagram. 3-11. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 33 for IC Pin Description. (Page 23) (Page 24) FB604 IC602... -
Page 26: Printed Wiring Board -Display Section
CDX-R30M/R3310/R3410/R3410S 3-12. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 17 for Circuit Boards Location. : Uses unleaded solder. LED902 LED905 S906 S911 LED905, S905 S905 S902 C903 C905 LED906, S906 LED906 LED961 S910 S922 (VOLUME) S961... -
Page 27: Schematic Diagram -Display Section
CDX-R30M/R3310/R3410/R3410S 3-13. SCHEMATIC DIAGRAM — DISPLAY SECTION — R972 IC971 R987 LED910 LED913 LED917 LED921 LED922 R988 C971 CN901 LED931 R924 LED931 R989 R976 LED912 R941 R925 R941 LED914 LED918 LED908 LED904 R978 R926 R942 R942 R971 R981 LED915 LED919... - Page 28 CDX-R30M/R3310/R3410/R3410S • IC BLOCK DIAGRAMS IC2 TC94A60MFG-301 (SERVO Board (1/2)) IC1 BA5968FP-E2 (SERVO Board (2/2)) 72 71 66 65 64 63 62 61 60 59 58 56 55 54 53 52 51 OPIN4+ LDCTL OUTR OUTF SLCO AUDIO DIGITAL VCOI AWRC OPIN4–...
- Page 29 CDX-R30M/R3310/R3410/R3410S IC401 BD3806FS-FE2 (MAIN Board (1/3)) FADER FADER FADER FADER (0~-58, (0~-58, (0~-58, (0~-58, C BUS -∞dB) -∞dB) -∞dB) -∞dB) GAIN+ATT LOGIC (+10~-29, -∞dB) 2ND ORDER LPF EFFECT (0dB~ EFFECT (0dB~ fc:OFF,80,120,160Hz +20dB,2dB STEP) +20dB,2dB STEP) 2ND ORDER Q: 0.707...
- Page 30 CDX-R30M/R3310/R3410/R3410S IC750 TDA8588AJ/N2/R1 (MAIN Board (2/3)) OUT FL- I2C BUS OUT FL+ OUT RL- PGND3 OUT RL+ INRL INFL SGND PROTECTION DIAGNOSTIC INFR INRR AC GND OUT RR+ PGND2 OUT RR- OUT FR+ STANDBY MUTE OUT FR- CHIP DETECT DIAGNOSTIC...
- Page 31 CDX-R30M/R3310/R3410/R3410S • IC PIN DESCRIPTIONS • IC3 MB90487APFV-G-142-BNDE1 (CD SYSTEM CONTROL) (SERVO BOARD (2/2)) Pin No. Pin Name Pin Description Servo 1.5 V power supply control signal output 2 to 6 — Not used. (Open) CD BUS0 Bus data signal input/output 0...
- Page 32 CDX-R30M/R3310/R3410/R3410S Pin No. Pin Name Pin Description XUART Sony-Bus/MC-Bus change signal input H: Sony-Bus, L: MC-Bus ZMUTE Zero detection mute signal output MECON CHK MECON rising detection signal input CDON CHK CDON rising detection signal input 69 to 74 —...
- Page 33 Tuner mute zero cross detection signal input BUIN Backup power supply detection signal input CD INTQ Not used in this set. (Open) DAVN RDS data block synchronization detection signal input Not used. (Open) UNISI SONY BUS data signal input UNISO SONY BUS data signal output...
- Page 34 CDX-R30M/R3310/R3410/R3410S Pin No. Pin Name Pin Description UNISCK SONY BUS clock signal output 61 to 63 Not used. (Open) SIRCS Remote control signal (infrared rays) input 65 to 67 Not used. (Open) Memory mode change signal input FLASH W Normally “H” input: Single chip mode, “L” after reset: Flash white mode Not used.
-
Page 35: Exploded Views
CDX-R30M/R3310/R3410/R3410S SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark number in the exploded views are not supplied. Example : 0 are critical for safety. -
Page 36: Front Panel Section
CDX-R30M/R3310/R3410/R3410S 4-2. FRONT PANEL SECTION not supplied (KEY board) not supplied LCD901 not supplied not supplied not supplied not supplied supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-2050-732-1 PANEL ASSY, FRONT (SV) (R3410S) -
Page 37: Cd Mechanism Section (1)
CDX-R30M/R3310/R3410/R3410S Ver. 1.1 4-3. CD MECHANISM SECTION (1) (MG-611TA-186//Q) not supplied (SENSOR board) not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3372-444-A CHASSIS (T) SUB ASSY 3-352-758-31 SCREW (M1.7), TOOTHED LOCK 3-253-729-11 SPRING (LTR), TENSION COIL... -
Page 38: Cd Mechanism Section (2)
CDX-R30M/R3310/R3410/R3410S 4-4. CD MECHANISM SECTION (2) (MG-611TA-186//Q) (including M901) M902 not supplied not supplied not supplied not supplied not supplied The components identified by Les composants identifiés par mark 0 or dotted line with mark une marque 0 sont critiques 0 are critical for safety. -
Page 39: Cd Mechanism Section (3)
CDX-R30M/R3310/R3410/R3410S 4-5. CD MECHANISM SECTION (3) (MG-611TA-186//Q) M903 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-348-993-01 WASHER 2-186-696-01 BRACKET (LEM-N) 2-186-699-01 GEAR (RA1) 3-345-648-91 SCREW (M1.4), TOOTHED LOCK A-1075-641-A ARM ASSY, ROLLER A-1083-636-A GEAR (LE) ASSY... -
Page 40: Cd Mechanism Section (4)
CDX-R30M/R3310/R3410/R3410S 4-6. CD MECHANISM SECTION (4) (MG-611TA-186//Q) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 2-186-700-01 GEAR (CHK1) 3-899-829-01 WASHER (SLIT) 3-344-223-01 WASHER 3-259-032-01 GEAR (LE2) 3-259-470-11 GEAR (LE1) A-1075-640-A CHASSIS (M) BLOCK ASSY 3-253-755-12 LEVER (D) -
Page 41: Electrical Parts List
CDX-R30M/R3310/R3410/R3410S SECTION 5 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark the parts list may be different from the they are seldom required for routine service. - Page 42 CDX-R30M/R3310/R3410/R3410S MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R925 1-216-815-11 METAL CHIP 1/10W S920 1-786-653-11 SWITCH, TACTILE (2,GP/DISC +) R926 1-216-809-11 METAL CHIP 1/10W S921 1-786-653-11 SWITCH, TACTILE (1,GP/DISC –) R927 1-216-809-11 METAL CHIP...
- Page 43 CDX-R30M/R3310/R3410/R3410S MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C502 1-162-964-11 CERAMIC CHIP 0.001uF D501 8-719-050-37 DIODE M1MA152WA-T1 C503 1-104-665-11 ELECT 100uF D502 6-500-137-01 DIODE BAT54HT1 C504 1-162-970-11 CERAMIC CHIP 0.01uF D510 6-501-013-01 DIODE BAT54ALT1G...
- Page 44 CDX-R30M/R3310/R3410/R3410S MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < JACK > 1-216-839-11 METAL CHIP 1/10W 1-216-843-11 METAL CHIP 1/10W 1-815-185-13 JACK (ANTENNA) 1-216-864-11 SHORT CHIP J330 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN, 1-216-864-11 SHORT CHIP...
- Page 45 CDX-R30M/R3310/R3410/R3410S MAIN SENSOR SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R532 1-216-845-11 METAL CHIP 100K 1/10W R677 1-216-821-11 METAL CHIP 1/10W R533 1-216-833-11 METAL CHIP 1/10W R678 1-216-821-11 METAL CHIP 1/10W R534 1-216-833-11 METAL CHIP...
- Page 46 CDX-R30M/R3310/R3410/R3410S SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-164-677-11 CERAMIC CHIP 0.033uF 1-208-912-11 METAL CHIP 0.5% 1/16W 1-125-777-11 CERAMIC CHIP 0.1uF 1-218-969-11 RES-CHIP 1/16W 1-125-777-11 CERAMIC CHIP 0.1uF 1-218-969-11 RES-CHIP 1/16W 1-125-777-11 CERAMIC CHIP 0.1uF...
- Page 47 CDX-R30M/R3310/R3410/R3410S Ver. 1.1 SERVO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-218-941-81 RES-CHIP 1/16W ACCESSORIES 1-218-973-11 RES-CHIP 1/16W ************ 1-218-973-11 RES-CHIP 1/16W 1-218-973-11 RES-CHIP 1/16W 1-479-077-11 REMOTE COMMANDER (RM-X151) 1-218-953-11 RES-CHIP 1/16W (EXCEPT R30M) 2-515-510-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
- Page 48 Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2005. 01 2005. 07 AEP and UK model addition in CDX-R30M.